Current Journal of Applied Science and Technology, ISSN: 2457-1024; 2231-0843 (old),Vol.: 25, Issue.: 6
Research on Preparation of Flocculants for Sugar Factory Wastewater Treatment
Chang-Yi Jin1 and Zu-Yu Liu1* 1Baise University, Baise, Guangxi, China.
Chang-Yi Jin1 and Zu-Yu Liu1*
1Baise University, Baise, Guangxi, China.
(1) Rares Halbac-Cotoara-Zamfir, Professor, Department of Hydrotechnical Engineering, “Politehnica” University of Timisoara, Romania.
(2) Aleksey Aleksandrovich Hlopitskiy, Professor, Department of Technology inorganic substances, Ukrainian State University of Chemical Technology, Ukraine.
(1) Narcis Barsan, University of Bacau, Romania.
(2) Başak Taşeli, Giresun University, Turkey.
Complete Peer review History: http://www.sciencedomain.org/review-history/23128
Polyacrylamide, formaldehyde and carbamide or guanidine carbonate were used as raw materials, cationic polyacrylamide flocculants were synthesized with Mannich reaction, effects of technical conditions on rate of turbidity removal were investigated, and synthesis technics was optimized. Experimental results showed that the flocculation properties of the products prepared with Mannich were better than ones of blank experiments (polyacrylamide). In the same dosage of flocculants, consumption of polyacrylamide in the products was smaller than (or equal to) 1/10 of polyacrylamide (blank experiments), reducing flocculation cost greatly. In the real wastewater treatment of sugar factories with the prepared products under optimum conditions, the turbidity removal rates was approaching to 90% or greater than 90% showing flocculation effectiveness was better. In addition, the wastewater of sugar factories was treated with prepared products and the removal of COD was 10～30%, which showed that using flocculating agents could reach the purposes of wastewater pretreatment.
Flocculant; polyacrylamide; carbamide; guanidine carbonate; wastewater.
Full Article - PDF Page 1-5
DOI : 10.9734/CJAST/2017/38533Review History Comments